Your question: Can you replace transmission cooler lines with rubber?

You can use rubber hose, but make sure it’s transmission cooler line rated. The pressure is quite low (12-15 psi). Double clamp it or use FI type clamps instead of the worm-drive style.

Can you use fuel hose for transmission cooling lines?

Registered. Fuel line hose isn’t up to the pressures normally associated with automatic transmissions. Use the proper stuff. If that thing splits or blows loose and hoses down any portion of your exhaust system hot enough to ignite it, your truck could end up burned to the ground.

Do you need transmission cooler lines?

Your car’s transmission lines are essential to preventing the transmission from overheating by carrying hot fluid away from the transmission until it is cooled and subsequently pumped back into the transmission.

Can you use rubber lines for transmission lines?

You can use rubber hose, but make sure it’s transmission cooler line rated. The pressure is quite low (12-15 psi). Double clamp it or use FI type clamps instead of the worm-drive style.

Are transmission cooler lines high pressure?

Its NOT only pressure you have to worry about, its also compatibility with the trans fluid. NOT aware of the pressures being any higher than other transmissions, so if you use “Transmission Cooler Hose” you should be fine.

IT IS IMPORTANT:  Frequent question: Can you use a UK car seat in America?

Does it matter which transmission cooler line goes where?

Generally the higher line on the radiator has fluid going INTO the transmission and the lower one goes back to the transmission, so the higher line has fluid coming out of it and the lower line sucks it back into the transmission.

How much does it cost to replace a transmission cooler line?

You will pay somewhere between $100 and $450 for a transmission cooler line replacement. The labor should be between $60 and $300, while parts can cost you anywhere from $40-$160.

What causes transmission cooler lines leak?

Transmission cooling lines leaking means either low-level of fluid or interrupted flow in the transmission. In both cases, the result is an overheated transmission that may stop functioning if the condition persists. Sometimes, it is difficult to spot the leak at the initial stage.

How serious is a transmission line leak?

A transmission leak spells serious trouble for your car, truck, or SUV. … If you have a leak, low fluid levels can affect the transmission’s performance and damage crucial parts. Transmission fluid is usually red to dark red; it’s pink if there’s a real problem.

Should I bypass radiator transmission cooler?

Bypassing your radiator transmission cooler would likely cause the fluid in your transmission to over heat causing premature transmission failure. If you are going to bypass it and hook up a better cooler … maybe but if you are eliminating a cooler al together that’s a terrible idea.

Can you use copper for transmission lines?

As copper has very good electrical characteristics. It has a high conductivity. So it is good material for transmission line but the cost of copper is very high as well as high specific gravity because of that it is not used for transmission lines.

IT IS IMPORTANT:  How much does it cost to replace a Subaru CVT transmission?