How much does it cost to replace condenser fan motor?

How long does a condenser fan motor last?

The average lifespan of an AC fan motor is about 12 years. An AC fan motor can last more than 12 years if it’s kept clean and cooled as needed. On the other hand, without annual maintenance checkups, your fan motor may only survive between one and three years.

How do I know if my condenser fan motor is bad?

Be aware of the following signs and symptoms of a bad AC fan motor.

  1. AC Fan Doesn’t Start. Even though you have the AC turned on, the fan does not start.
  2. AC Fan Doesn’t Stop. …
  3. Slow Rotating Blades. …
  4. Outside Fan Blades Are Still. …
  5. Rattling, Humming, and Buzzing Noises. …
  6. AC Runs Intermittently. …
  7. No Cold Airflow.

How much is it to replace fan motor?

So how much does it cost to replace a fan motor? It will cost you about $300 to $600 to replace your AC fan motor.

IT IS IMPORTANT:  Why are seat belts and headrests in cars important?

How much does it cost to replace an AC blower motor?

Replacing a blower motor costs $450 on average with a typical range of $250 to $800. With a warranty, you might pay as little as $150 for labor alone. For high-end models, like those with large motors or access issues, you might pay as much as $2,000.

What causes a condenser fan motor to fail?

The main causes of failure are loss of lubricant, a failed run capacitor, a failed bearing in a belt drive, a little water dripping into the windings or a voltage problem.

What happens when condenser fan fails?

When the condenser overheats, all of the components of the AC system will begin to overheat until they eventually get hot enough to burn and emit an odor. … A failed fan will not only fail to produce cold air, but can even result in damage to the AC system due to overheating.

How much is a condenser motor?

The average cost of a condenser fan motor is between $300 and $500 (not including installation). If the compressor breaks, you are looking at a much costlier problem which could cost up to $2000. In some cases, your fan motor may be under warranty.

What causes a condenser fan motor to overheat?

Lack of maintenance: This is probably the most common reason that causes condenser fan motors to overheat and shut off. Proper and regular lubrication of the fan motor is necessary for the motor to run smoothly. … If the motor is too small, it will run too hard and then overheat.

IT IS IMPORTANT:  What benefits do electric cars have?

When replacing a fan motor in an HVAC condenser What else should you replace?

Every time you replace a condenser fan motor, you should also replace the A.C.’s run capacitor, which is a cylinder-shaped device that helps to start or run motors. To replace it, again take down all technical data on the unit, and note wiring colors and positions before removing it with a screw driver.

What is the cost of AC motor?

Top Selling General Purpose Motors Price List in India

Latest General Purpose Motors Models Price Discount
SONEE-DX 3HP 4 Pole Copper Single Phase AC Electric Motor with 1 Year Warranty ₹10761 28 % off
SONEE-DX 1HP 4 Pole Copper Single Phase AC Electric Motor with 1 Year Warranty ₹6439 35 % off

How long should an AC blower motor last?

The blower motor in your home or office should last anywhere from 10 to 20 years. Modern sealed bearings and sealed bushings can push the lifespan to its maximum of 20 years.

How long does it take to replace a blower motor?

It takes between 45 to 90 minutes for a HVAC specialist to: replace the blower motor, adjust it, clean the fan, test it and assemble the furnace back together. The biggest challenge if you’re doing it yourself is getting the assembly out.